• <div id="osacy"><li id="osacy"></li></div><small id="osacy"><li id="osacy"></li></small><div id="osacy"></div><div id="osacy"></div>
  • <div id="osacy"><div id="osacy"></div></div>
  • <div id="osacy"></div>
  • <div id="osacy"></div>
  • <small id="osacy"><li id="osacy"></li></small>
  • <div id="osacy"></div>
    <div id="osacy"><li id="osacy"></li></div>
  • <small id="osacy"><li id="osacy"></li></small>
    您好,歡迎光臨萊州中科聚峰有限公司官方網站
    15053524111
    混凝土攪拌機行業持續領跑者!
    點擊撥打服務熱線:15053524111
    您的位置: 首頁 > 混凝土攪拌機資訊>>漲知識:混凝土攪拌車的操作流程 你都做了嗎?

    全國服務熱線

    400-879-1999
    混凝土攪拌機資訊 /news

    漲知識:混凝土攪拌車的操作流程 你都做了嗎?

    來源:http://www.thecxg.com/ 日期:2020-09-22 瀏覽量:
    TAG:混凝土攪拌機,自動混凝土攪拌機,小型攪拌機
    概述:一、啟動前應對機械系統各部位認真進行檢查,確認良好后方可啟動。1、 Before starting, all parts of the mechanical system sho
    一、啟動前應對機械系統各部位認真進行檢查,確認良好后方可啟動。
    1、 Before starting, all parts of the mechanical system should be carefully checked, and the machine can be started only after it is confirmed to be good.
    二、啟動前,應將攪拌操縱桿放在“空檔”位置。
    2、 Before starting, the mixing control lever should be placed in the "neutral" position.
    三、啟動后,應將攪拌操縱桿放在“卸料”位置,放去筒內積水。
    3、 After start-up, the mixing control rod should be placed in the "unloading" position to drain the water in the cylinder.
    四、裝料時,攪拌操作桿應放在“裝料”位置。
    4、 When loading, the mixing lever should be placed in the "loading" position.
    五、運輸前,卸料槽必須固定在“行駛”位置,防止擺動。
    5、 Before transportation, the discharge chute must be fixed in the "running" position to prevent swing.
    六、操作操縱桿時,應在“空檔”位置稍作停留后方可動至下一個位置。
    6、 When operating the control lever, it should be in the "neutral" position for a while before moving to the next position.
    七、搞好文明施工,桶內多余材料不準隨便亂倒。卸料后必須對攪拌筒、料槽、托輥等部位進行清洗。
    7、 Do a good job in civilized construction, and do not pour the surplus materials in the barrel randomly. After unloading, the mixing drum, material trough, idler and other parts must be cleaned.
    八、人進入筒內清除砼結塊時,應將車輛熄火,拔下電門鑰匙,筒外設人監護。
    8、 When a person enters the cylinder to remove the concrete caking, the vehicle shall be turned off, the switch key shall be removed, and a person shall be assigned outside the cylinder for supervision.
    混凝土攪拌車是一種特殊車輛,并不是所有會開車的司機都會開攪拌車,如果操作不當會引起翻車、液壓泵、馬達、減速機過快磨損甚至出現嚴重后果。
    Concrete mixer is a kind of special vehicle. Not all drivers who can drive can drive the truck. If the truck is not operated properly, it will cause rollover, excessive wear of hydraulic pump, motor and reducer, and even serious consequences.
    1.起動攪拌車之前,應把攪拌筒操作手柄放在“停止”位置。
    1. Before starting the mixer truck, put the mixing drum operation handle at the "stop" position.
    2.攪拌車起動發動機后,應使攪拌筒在低速下轉動10分鐘左右,使液壓油溫升到20℃以上后方可工作。
    2. After the mixer starts the engine, make the mixing drum rotate at low speed for about 10 minutes, and make the hydraulic oil temperature rise to above 20 ℃ before working.
    3.攪拌車在露天停放時,裝料前應將攪拌筒反轉,將積水和雜物排出,以保證混凝土的質量。
    3. When the mixer truck is parked in the open air, the mixing drum should be reversed before loading to discharge water and debris, so as to ensure the quality of concrete.
    4 . 攪拌車在運輸混凝土時,要保證滑斗放置牢固,防止因松動造成擺動,在行進中打傷行人或影響其它車輛正常運行。
    4. When the mixer truck is transporting concrete, it is necessary to ensure that the sliding bucket is placed firmly, so as to prevent swing caused by looseness, which may injure pedestrians or affect the normal operation of other vehicles.
    5 . 攪拌車裝運攪拌好的混凝土時,攪拌筒轉速為2-10轉/分,在運輸過程中,平坦路面上攪拌筒轉速保證在2-3轉/分,行駛在側傾坡度大于50的路面,或左右晃動較大的路面時,應停止攪拌旋轉,待路況好轉后再恢復攪拌旋轉。
    5. When the mixer truck transports the mixed concrete, the speed of the mixing drum is 2-10 rpm. In the process of transportation, the rotation speed of the mixing drum should be kept at 2-3 rpm on the flat road surface. When driving on the road with a roll slope greater than 50, or the road with large left and right shaking, the mixing rotation should be stopped and the mixing rotation can be resumed after the road conditions are improved.
    6 . 混凝土攪拌車運送混凝土的時間不能超過攪拌站規定的時間。運送混凝土途中,攪拌筒不得長時間停轉,以防混凝土產生離析現象。司機應時常觀察混凝土情況,發現異常及時通報調度室,申請做出處理。
    6. The time of concrete mixer truck transporting concrete shall not exceed the time specified by mixing station. During the transportation of concrete, the mixing drum shall not stop for a long time to prevent the concrete from segregation. The driver shall observe the concrete condition from time to time, report to the control room in case of any abnormality, and apply for handling.
    7 . 攪拌車車內裝有混凝土時,在現場停滯時間不得超過1小時,如超時應立即要求現場負責人給予及時處理。
    7. When the mixer truck is filled with concrete, the stagnation time on the site shall not exceed 1 hour. If the truck exceeds the time limit, the person in charge of the site shall be required to deal with it in time.
    8 . 攪拌車運送混凝土塌落度不得低于8cm。從混凝土入罐到排出,氣溫高時不得超過2小時必須排出,陰雨天氣溫度低時,不得超過2.5小時。
    8. The slump of concrete transported by mixer truck shall not be less than 8cm. From the concrete entering into the tank to discharging, it shall not exceed 2 hours when the temperature is high, and it shall not exceed 2.5 hours when the temperature is low in rainy days.
    9 . 攪拌車在排出混凝土之前,應使攪拌筒在10-12轉/分的轉速下轉動1分鐘,再進行排料。
    9. Before discharging concrete, the mixer truck should rotate the mixing drum at the speed of 10-12 rpm for 1 minute before discharging.
    相關標簽:混凝土攪拌車
    技術支持:山東鑫諾商 網站地圖    TXT    XML 本網站部分資源來自互聯網,如有侵權,請聯系我們及時刪除

    魯公網安備 37068302000238號

    免费啪视频观试看视频软件 <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <文本链> <文本链> <文本链> <文本链> <文本链> <文本链>

    截屏,微信識別二維碼

    微信號:

    點擊微信號復制,添加好友

     打開微信

    <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <文本链> <文本链> <文本链> <文本链> <文本链> <文本链>